Garage Find!
This “garage find” had been sitting for close to 20 years. I’ve gone through this bike front to back. I thought it was an original paint bike but, I realized it’s not the case. It has a very high quality, single stage paint job, the stripes are hand done and it’s correct in every way from original. Other than clean up and polishing I have done the following;
1, Clean pistons and send out cylinders for Nikisil coatings
2, Disassembled heads, reground valves and seats
3, Installed new rings and top end gaskets
4, Disassembled and ultrasonically cleaned carbs
5, Replaced points, plugs and wires set timing and dwell
6, Removed swing arm, replaced carrier bearing, inspected U-joint and repacked pivot bearings
7, Disassembled, cleaned, inspected and resealed bevel drive
8, Repacked wheel bearing and replaced tires,
9, Remove, clean and lube brake pivots
10,Reseal forks
11, Repair wiring
12, Lubed or replaced cables and twist grip
13, Installed mini Denso alternator and rebuilt Bosch starter
14, Install new battery
15, Remove, clean and lube headlight switch
16, Clean and removed rust from inside fuel tank, replace pet cocks and fuel line
17, Install new air filter
18, replace all fluids
19, Remove transmission, replace rear engine oil seal and reseal transmission. Clean and inspect clutch.
PRICE TBA.